化工新型材料

化工新型材料 ›› 2022, Vol. 50 ›› Issue (12) : 242-247. DOI: 10.19817/j.cnki.issn1006-3536.2022.12.045

开发与应用

CeO₂/TiO₂-Ag₃PO₄复合催化剂去除废水中LAS的性能研究

李大军, 贺惠, 李芳芳

作者信息 +

Study on the performance of CeO₂/TiO₂-Ag₃PO₄ composite catalyst to remove LAS in wastewater

Li Dajun, He Hui, Li Fangfang

Author information +

文章历史 +

Received		Published
2021-08-06		2022-12-20
Issue Date	Revised Date
2022-12-30	2021-08-06

PDF

摘要

采用化学共沉淀法制备了CeO₂掺杂不同含量的TiO₂-Ag₃PO₄复合光催化剂(CeO₂/TiO₂-Ag₃PO₄),考察了该催化剂对LAS废水中有机物的光催化降解性能。结果表明:CeO₂掺杂比为0.5％的三元复合光催化剂,对溶液中甲基蓝(MB)和十二烷基苯磺酸钠(SDBS)均有最佳的降解效率,催化剂最佳投加量为1.00～1.10g/L,紫外光照射30min,在不调节溶液pH条件下,对SDBS的光催化降解效率可高达99.86％;同等反应条件下,SDBS的去除率随着溶液初始浓度的升高而降低,通过动力学拟合分析,发现该催化剂对SDBS的催化降解反应遵循二级动力学特性。催化剂的光催化活性在酸性溶液条件下明显要优于中性和碱性条件;重复使用5次,催化剂降解SDBS仍表现出较好的循环稳定性和高效催化性;光催化机理实验表明紫外光下复合光催化剂降解SDBS的过程中主要的活性物种是超氧自由基。因此,该方法制备的负载型催化剂具有催化活性高、性能相对稳定、可重复循环使用等优点,对LAS废水和印染废水后处理环节均具有潜在的应用前景。

Abstract

The TiO₂-Ag₃PO₄ composite photocatalyst (CeO₂/TiO₂-Ag₃PO₄) doped with rare earth CeO₂ was prepared by chemical co-precipitation method,and the photocatalytic degradation performance of the catalyst on the organic matter in LAS wastewater was further investigated.The experimental results showed that the ternary composite photocatalyst with a CeO₂ doping ratio of 0.5wt% had the best degradation efficiency for MB and SDBS in the solution.The optimal dosage of the catalyst was 1.00～1.10g/L and the photocatalytic degradation efficiency of SDBS was as high as 99.86% in the ultraviolet light for 30min under the condition of not adjusting the pH value of the solution.Under the same reaction conditions,the removal rate of SDBS decreased with the increase of the initial concentration of the solution.Through kinetic fitting analysis,it was found that the catalytic degradation reaction of the catalyst to SDBS followed the second-order kinetic characteristics.The photocatalytic activity of the catalyst in acidic solution was obviously better than that in neutral and alkaline conditions.The catalyst degrades SDBS still showed good cycle stability and high-efficiency catalytic performance after repeated use for 5 times.Photocatalytic mechanism experiments showed that the main active species,in the degradation of SDBS by the composite photocatalyst in ultraviolet light,is superoxide radicals.Therefore,the supported catalyst prepared by the method had the advantages of high catalytic activity,relatively stable performance,recyclable use,etc.,and possessed potential application prospects for the post-treatment links of LAS wastewater and printing and dyeing wastewater.

关键词

化学共沉淀法 / 紫外光催化 / 复合催化剂 / 阴离子表面活性剂 / 稀土氧化物掺杂

Key words

chemical co-precipitation method / ultraviolet photocatalysis / composite catalyst / anionic surfactant / rare earth oxide doping

引用本文

引用格式 ▾

CeO₂/TiO₂-Ag₃PO₄复合催化剂去除废水中LAS的性能研究[J]. 化工新型材料, 2022, 50(12): 242-247 DOI:10.19817/j.cnki.issn1006-3536.2022.12.045

登录浏览全文

4963

注册一个新账户忘记密码

参考文献

原文顺序 | 出版日期 | 本文引用

[1] 丁小龙,祝媛媛.表面活性剂洗涤剂的成分及性能研究[J].当代化工研究,2021(2):31-32.
[2] 黄文,刘志敏,成应向.低浓度LAS对活性污泥性质和去除污染物行为的影响[J].环境工程学报,2013,7(9):3390-3396.
[3] 余姝洁,李名.纳米材料在环境污染治理中最新研究及问题[J].环境科学与技术,2016,39(S1):155-158.
[4] 朱鸿杰.新型铁基Z-scheme型光催化剂构建机理及光催化性能研究[D].南京:南京大学,2020.
[5] Xiong Z,Zhao X S.Titanate@TiO₂ core-shell nanobelts with an enhanced photocatalytic activity[J].Journal of Materials Chemistry A,2013,1(26):7738-7744.
[6] 蒋洪静,郭满囤.我国表面活性剂LAS废水的处理技术进展[J].山西化工,2008,28(1):28-31.
[7] 孙慧君,张丽.光催化氧化技术在造纸废水处理中的应用[J].中华纸业,2019,40(18):33-38.
[8] 戴春爱,高常锐,冯琳.Cu网负载CeO₂-TiO₂微纳米复合材料(CeO₂-TiO₂)/Cu的水热制备与性能[J].高等学校化学学报,2013,34(9):2057-2062.
[9] Yi Z,Ye J,Kikugawa N,et al.An orthophosphate semiconductor with photooxidation properties under visible-light irradiation[J].Nature Materials,2010,9(7):559-564.
[10] 祝一锋,黄小钢,朱文仙,等.原位光催化聚合制备聚(N-乙烯基咔唑)/TiO₂纳米复合材料及其光催化性能[J].材料导报,2020,34(2):147-152.
[11] 张博,张太亮,谢晋,等.Ag₃PO₄@MMT复合催化剂的制备及其可见光催化降解罗丹明B[J].应用化工,2019,48(11):2647-2651.
[12] 赵宝明,建艳飞,姜泽宇,等.稀土氧化物EuOx对Pt/CeO₂材料在甲苯催化燃烧中的显著促进机制[J].催化学报,2019,40(4):93-105.
[13] 王家明,蒋颉,岳军,等.稀土元素改性kappa相铈锆复合氧化物的性能研究[J].金属功能材料,2019,26(5):56-62.
[14] 马惠言,周丹,刘聚明,等.SO^2-₄/CeO₂-TiO₂光催化材料的制备与光谱表征[J].光谱学与光谱分析,2017,37(10):3315-3320.
[15] 钱进,薛瑶,敖燕辉,等.CeO₂/NaNbO₃复合物的水热合成及其光催化性能的提高[J].催化学报,2018,39(4):682-692.
[16] 王委委,宋肖飞,蔡以兵,等.三元脂肪酸共晶物/二氧化硅定形相变复合材料的制备及其热性能[J].材料科学与工程学报,2020,38(1):74-79.
[17] 李大军,贺惠,杨丽.TiO₂-Ag₃PO₄光催化剂的制备及其紫外光催化性能[J].化工环保,2016(1):53-58.
[18] 刘红,徐红.硫堇紫外光度法测定十二烷基苯磺酸钠[J].化工时刊,2012,26(6):32-34.
[19] 余婕,马红竹,何文妍,等.三维电极体系对SDBS模拟生活污水的电催化降解[J].环境科学与技术,2014,37(10):126-130,176.
[20] 姚秉华,杨莉,杨国农,等.复合光催化剂CeO₂/TiO₂的制备及性能研究[J].化学研究与应用,2004,16(4):463-465.
[21] 刘程,李国宁,张曼霞,等.基于卟啉基多孔有机聚合物的CO₂吸附及催化性能[J].功能高分子学报,2020,33(6):532.
[22] 郭桂全,胡巧红,邢翠娟,等.g-C₃N₄/Fe₂O₃复合光催化剂的制备,降解性能及其机理[J].化学研究与应用,2020,32(10):162-166.
[23] 鲁晶,刘冬梅,刘世光,等.纳米TiO₂颗粒与腐殖酸和SDBS的相互作用机制[J].哈尔滨工业大学学报,2015,47(8):21-24.
[24] Ogawa Takuya,Kawase Yoshinori.Effect of solution pH on removal of anionic surfactant sodium dodecylbenzenesulfonate (SDBS) from model wastewater using nanoscale zero-valent iron (nZVI)[J].Journal of Environmental Chemical Engineering,2021.DOI:10.1016/j.jece.2021.105928.
[25] Sara Dominguez,Maria J Rivero,Pedro Gomez,et al.Kinetic modeling and energy evaluation of sodium dodecylbenzenesulfonate photocatalytic degradation in a new LED reactor[J].Journal of Industrial and Engineering Chemistry,2016,37(1):237-242.
[26] 李翠霞,孙会珍,金海泽,等.RGO改性介孔TiO₂薄膜光催化同步去除Ni²⁺和SDBS[J].中国环境科学,2021,41(4):1663-1671.
[27] 苏志伟,陈鲁川,雷乐成,等.BDD电极氧化降解SDBS的研究[J].高校化学工程学报,2020,34(6):1545-1550.
[28] Javad Saien,Amir Azizi.Simultaneous photocatalytic treatment of Cr(Ⅵ),Ni(Ⅱ) and SDBS in aqueous solutions:evaluation of removal efficiency and energy consumption[J].Process Safety and Environmental Protection,2015(95):114-125.
[29] 刘学军,苏冰野,谭昭怡,等.放射性洗涤废水的SDBS光催化降解研究[J].化学研究与应用,2019,31(1):155-161.
[30] Li H,Zang L,Shen F,et al.Tubular g-C₃N₄/carbon framework for high-efficiency photocatalytic degradation of methylene blue[J].RSC Advance,2021,30(11):18519-18524.
[31] Wu H,Dou X,Deng D,et al.Decolourization of the azo dye Orange G in aqueous solution via a heterogeneous Fenton-like reaction catalysed by goethite[J].Environmental Technology,2012,33(13-15):1545-1552.
[32] Yan B,Xu D C,Liu Z,et al.Degradation of neurotoxin β-N-methylamino-L-alanine by UV254 activated persulfate:kinetic model and reaction pathways[J].Chemical Engineering Journal,2021,DOI:10.1016/j.cej.2020.127041.
[33] Fang Yuanxing,Zheng Yun,Fang Tao,et al.Photocatalysis:an overview of recent developments and technological advancements[J].Science China(Chemistry),2020,63(2):149-181.
[34] Wei Weiqin,Ouyang Shuxin,Zhang Tierui.Perylene diimide self-assembly:from electronic structural modulation to photocatalytic applications[J].Journal of Semiconductors,2020,41(9):105-131.
[35] Wang Guangli,Xu Jingjuan,Chen Hongyuan.Progress in the studies of photoelectrochemical sensors[J].Science in China(Series:Chemistry),2009,52(11):1789-1800.