采用低温等离子体技术处理含聚丙烯酰胺(PAM)废水,研究了放电电压、放电时间、溶液pH对不同浓度PAM溶液化学需氧量(COD)降解率的影响规律,同时还研究了不放电条件下PAM溶液pH以及放电条件下放电时间对不同浓度PAM溶液黏度去除率的影响,考察了放电条件下pH对质量浓度1.0g/L PAM溶液黏度去除率的影响规律。通过正交试验确定影响PAM溶液COD降解率的主次顺序为:放电时间>放电电压>溶液浓度>溶液pH。在放电时间5h、放电电压40kV、PAM溶液质量浓度1.0g/L、pH=1.5时,COD降解率最佳,可达85.74%。
Non-thermal plasma was applied to treat polyacrylamide(PAM) wastewater.The influence rule of PAM wastewater initial pH value,solution concentration and discharge time,discharge voltage on COD degradation rate was investigated.At the same time,the effect of pH value and discharge time of PAM solution on the viscosity removal rate of PAM solution was also studied.Then,the effect of pH value on the viscosity removal rate of 1.0g/L PAM solution was studied separately.Through orthogonal test,the factors affecting the COD degradation rate of PAM wastewater were determined as follows:discharge time>discharge voltage>solution concentration>wastewater initial pH value.The COD highest removal rate of PAM wastewater reached 85.74%,when the optimal conditions were as follows:discharge voltage 40kV,discharge time 5h,solution concentration 1.0g/L,pH 1.5.
[1] Ma Jiangya,Fu Kun,Fu Xue,et al.Flocculation properties and kinetic investigation of polyacrylamide with different cationic monomer content for high turbid water purification[J].Separation and PurificationTechnology,2017,182:134-143.
[2] Fares Almomani,Banu Ormeci.Measurement of polyacrylamide polymers in water and wastewater using an in-line UV-Vis spectrophotometer[J].Journal of Environmental Chemical Engineering,2014,2(2):765-772.
[3] 闫佳,张东晨,徐敬尧,等.煤泥对含聚污水中聚丙烯酰胺的吸附动力学研究[J].煤炭科学技术,2016,44(2):185-190.
[4] Saeed Farrokhpay,Lev Filippov.Aggregation of nickel laterite ore particles using polyacrylamide homo and copolymers with different charge densities[J].Powder Technology,2017,318:206-213.
[5] 荣俊锋.等离子体协同紫外光催化净化聚丙烯酰胺废水[J].应用化工,2016,45(8):1535-1538.
[6] 荣俊锋,陆雪玉,张帅,等.填料吸附-等离子体氧化协同处理苯酚废水[J].环境工程,2016,45(12):53-57.
[7] 屈广周,李杰,梁冬丽,等.低温等离子体技术处理难降解有机废水的研究进展[J].化工进展,2012,31(3):662-670.
[8] Tichonovas M,Krugly E,Racys V,et al.Degradation of various textile dyes as wastewater pollutants under dielectric barrier discharge plasma treatment[J].Chemical Engineering Journal,2013,229(8):9-19.
[9] 王保伟,董博,刘震,等.非平衡等离子体降解废水中有机污染物研究进展[J].环境工程学报,2015,9(10):4613-4622.
[10] Biljana P D,Goran M R,Bratislav M O,et al.Decolorization of reactive textile dyes using water falling film dielectric barrier discharge[J].Journal of Hazardous Materials,2011,192(2):763-771.
[11] Wen Y Z,Shen C S,Ni Y Y,et al.Glow discharge plasma in water:a green approach to enhance ability of chitosan for dye removal[J].Journal of Hazardous Materials,2012,201-202(1):162-169.
[12] Valsero M H,Molina R,Schikora H,et al.Removal of cyanide from water by means of plasma discharge technology[J].Water Research,2013,47(4):1701-1707.
[13] Rong Junfeng,Zhu Kaixun,Chen Minggong.Study on purification technology of polyacrylamide wastewater by non-thermal plasma[J].Plasma Science and Technology,2019,21(5):054008.
[14] 陈明功,齐永涛,张鑫敏,等.低温等离子体与絮凝剂处理印染废水的协同效应[J].中国环境科学,2010,30(9):1207-1212.
[15] 盛楠,陈明功,孙逸玫,等.低温等离子体协同填料床吸附净化甲醇废水[J].中国环境科学,2017,68(6):2546-2554.
[16] 陈明功,荣俊锋,余东旭,等.DBD反应器中催化剂颗粒直径对放电功率的影响[J].高校化学工程学报,2012,26(5):889-894.
基金资助
国家级大学生创新创业训练计划项目(201910361079);安徽理工大学青年基金资助项目(12661)
PDF
(1478KB)
